91473 Roofing and Siding
Project consists of roof replacement of Fire Station 33 in Charlotte, NC. This work includes the provision of labor, material, equipment, supervision, an administration.
Replace the existing built-up asphalt roof system with the specified two-ply modified bitumen roof system on 2 roof areas totaling approximately 9,700 square feet of roof area.
The purpose of this contract is to perform roof replacement and building envelope repairs for two buildings located at 4800 and 4814 West Boulevard, Charlotte, North Carolina. Estimated term to be less than one year.
Project consists of roof replacement at Fleet Management, Charlotte, North Carolina. This work includes
the provision of labor, material, equipment, supervision and administration to includes:
1. Roof Areas A, B, C and D:
a. Complete removal of all existing metal roof, insulation, bituminous flashings and metal flashings,
gutters and downspouts, abandoned vents and discard.
b. Furnish and install new roof insulation, structural metal roof panels and all associated
miscellaneous work as specified herein.
c. Furnish and install new gutters, downspouts and bituminous and metal flashings.
2. Roof Area E:
a. Furnish and install new roof insulation, fully adhered PVC roof membrane and all associated
miscellaneous work as specified herein.
b. Furnish and install new gutters, downspouts and bituminous and metal flashings.
Design and construct a new 2-story, 3-bay firehouse at 14,626 square feet, to be located at 5800 North Tryon Street. This facility will be a new infill firehouse that will alleviate high call volume for surrounding firehouses. A new firehouse must be built when a new “point of dispatch” is required in order to meet response time standards. The proposed facility will be located on a 2.03-acre parcel that facilitates the redevelopment of abandoned/underutilized sites and vacant sites. This location and site selection shall meet the City of Charlotte Policy for Sustainable City Facilities and Charlotte Fire Department Facilities Master Plan.
This project will pursue LEED certification. The site will incorporate solar panels and a geothermal well system with water source heat pumps.
Phase II Animal Care & Control renovations will address non-compliant issues per the NC Department of Agriculture and Consumer Services, Animal Welfare Section (NCDA&CS) Inspection reports issued in 2018, 2020, and 2021. Phase II will address renovations for separation of species, inadequate ventilation surfaces not impervious to moisture, slab repair, additional square footage for dog and cat housing, and if funding is available fencing and gate replacement for dog kennels. This phase also will address ADA Barrier renovations to meet international ADA code requirements.
The facility is located at 8315 Byrum Drive, near the airport. This facility is just under 30 years old and the renovations required are a direct response to the NCDA&CS inspection reports. Also, the project will incorporate renovations to address ADA barriers in the facility, such as door hardware, signs, plumbing, minor parking lot curbing, etc.
CMPD background checks will be required for all construction staff, vendors, and anyone occupying the site during construction and deliveries.
This contract will be to provide roof and sealant replacement on the building at
4824 West Boulevard for Charlotte Douglas International Airport, Charlotte, North Carolina. This will be a complete removal of existing roofing membrane, insulation, flashings, sheet metal flashings, gutters, and downspouts, and complete removal of all existing backer rod and sealant at exterior wall brick control joints; repair and/or replacement of rusted and/or deteriorated metal deck, and the installation of new insulation, cover board, mechanically fastened 60 mil TPO membrane and associated flashings, sheet metal flashings, gutters and downspouts, and backer rod and sealant at exterior wall brick control joints and all associated miscellaneous work. The contractor must also provide temporary protection of contents in the building and cleanup of debris associated with removals. The roof has exceeded the expected lifespan and is currently 30+ years old. The project term will be 180 days.
| Components | Areas A, B, C and D |
| Membrane | Fully adhered Hypalon-based single-ply membrane |
| Cover Board | 1/2 inch gypsum fiber roof board |
| Insulation | Two (2) layers of 2-inch extruded polystyrene (XPS) |
| Underlayment | 5/8 inch gypsum fiber roof board |
| Deck | Metal deck except that parts of Area A has acoustical metal deck |
| Drainage | Internal roof drains with overflow scuppers |
| Slope | 1/4 inch per foot structural slope with XPS insulation drainage crickets |
Approx. heights of roofs to top of parapets above grade is 50 feet.
Approx.. square footage of roof project is 18,313 sq.ft.
(PSR# 1206)
Roofing Replacement of various Wastewater Treatment Plants’ structures: McDowell, Irwin, Sugar Creek and McAlpine. Replacement consists of complete tear off of existing roof down to substrate. Minor mechanical and electrical relocation/replacement work will be performed, if necessary.
Roofing Replacement of various Water Treatment Plants and Lift Stations. The Project consists of replacing roofing systems at Sharon Repump Station, Hoskins Booster Pump Station, and Plaza Booster Pump Station, as well as removing existing skylight and install clerestory and roof structure at Plaza Booster Pump Station and replacing the skylight at Idlewild Booster Pump Station. complete tear-off of the existing roof down to the substrate. Minor mechanical and electrical relocations and re-hook-ups are required.